| |
VF-31E, VF-609, VF-61, VF-62
Clean Dry Fuels and Oils with High Performance
- Wide variety of applications
- Free and emulsified water to less than 5 ppm
- 1/2 micron particulate removal
- Provides protection against “slugs” of water
- Pressure increase signals cartridge change
Datasheet 2076 - VF-62 Filter Housings PDF (519 KB)
Datasheet 1997 - Small Filter Housings (VF-31E, VF-61, VF-609) (158 KB)
|
|
|
|
VF-31E |
VF-609 |
VF-61 |
VF-62 |
FEATURES
|
VF-61 connected to a
diesel fuel dispenser
|
- Wide variety of applications
- Free and emulsified water to less than 5 ppm
- 1/2 micron particulate removal
- Provides protection against “slugs” of water
- Pressure increase signals cartridge change
These filter housings are versatile housings designed for use with several different high performance Aquacon® and other filter cartridges. Refer to the cartridge selection table on page 3 for application and other details.
Aquacon® cartridges filter out water by chemically locking it into layers of super-absorbent media. Water capacity is as much as 1.5 quarts, depending on the specific vessel and cartridge. These cartridges also effectively filter out dirt, rust and other particulates. (See caution, back cover.)
As an Aquacon® cartridge reaches its water-holding limit, the media expands very rapidly and restricts the flow. The pressure drop will rapidly increase, signaling the need to change cartridges.
The VF-61, with Aquacon® ACO series cartridges installed, has become the standard for low flow rate full flow aviation fuel monitor applications.
APPLICATIONS
- Jet Fuel
- Avgas
- Motor Gasoline
- Diesel Fuel
- Biodiesel
- Selected Solvents
- Oils:
- Insulating
- Hydraulic
- Lubricating
- Compressed Air
- Other Gasses
DIMENSIONAL DRAWINGS
VF-31E
|
|
VF-609
|
|
VF-61
|
|
VF-62
|
|
FILTER CARTRIDGE SELECTION TABLE
Housing
P/N |
Product
being filtered |
Application |
Cartridge
P/N |
Data Sheet |
Type |
Micron |
Flow Rate
(GPM) |
VF-31E |
Jet Fuel & Avgas(1) |
Dirt & Free water |
ACO-21001L |
|
Aquacon®
(Absorbent) |
0.5 |
1-15 |
Motor Gasoline |
AC-21005 |
|
5 |
Gasohol |
Dirt |
FOG-21005 |
N/A |
Paper filter |
5 |
1-15 |
Diesel(1) |
Dirt & Free water |
AD-21025 |
|
Aquacon®
(Absorbent) |
25 |
1-15 |
Oils |
AC-21005 |
|
5 |
Varies with oil viscosity(2) |
AD-21025 |
|
25 |
Air/Gas |
ACA-210 |
|
1 |
100 SCFM @ 100 psig |
Dirt |
FOS-210PLP5 |
N/A |
Synthetic Filter |
0.5 |
VF-61 |
Jet Fuel & Avgas(1) |
Dirt & Free water
|
ACO-512P3L |
|
Aquacon®
(Absorbent) |
0.3 |
5-50 |
ACO-51201L |
0.5 |
5-50 |
OS-51288 |
|
Coalescer/
Separator |
0.5 |
Jet: 5-35 |
Avgas: 5-45 |
Motor Gasoline |
AC-51205 |
|
Aquacon®
(Absorbent) |
5 |
5-50 |
Diesel(1) |
AD-51225 |
|
25 |
15-50 |
OS-51286 |
|
Coalescer/
Separator |
5 |
5-18 |
Oils |
AC-51205 |
|
Aquacon®
(Absorbent) |
5 |
Varies with oil viscosity(2) |
AD-51225 |
|
25 |
Solvents |
ASL-51201 |
|
1 |
5-50 |
ALL
|
Dirt |
FO-512PL1/2 |
|
Paper Filter |
0.5 |
Fuels: 5-50
Oils: Varies with oil
viscosity(3) |
FO-512PL05 |
5 |
FO-512PL25 |
25 |
FOS-512PL25 |
|
Synthetic Filter |
25 |
VF-609 |
Jet Fuel & Avgas(1)
|
Dirt & Free water |
ACO-609P3L |
|
Aquacon®
(Absorbent)
|
0.3 |
15-36 |
ACO-60901L |
0.5 |
ACO-60905L |
5 |
OS-60988 |
|
Coalescer/
Separator |
0.5 |
Jet: 5-35 |
Avgas: 5-45 |
Diesel(1)
|
AD-60925 |
|
Aquacon®
(Absorbent) |
25 |
15-30 |
OS-60986 |
|
Coalescer/
Separator |
5 |
5-18 |
VF-62 |
Jet Fuel &
Avgas (4) |
Dirt & Free water |
ACO-52401L |
|
Aquacon®
(Absorbent) |
0.5 |
10-100 USGPM (5) |
Motor Gasoline |
AC-52405 |
5 |
10-100 USGPM |
Diesel Fuel |
AD-52425 |
25 |
30-100 USGPM |
Oils |
AC-52405 |
5 |
Varies with viscosity
See Form #1709 |
AD-52425 |
25 |
Solvents |
ASL-52401 |
1 |
10-100 USGPM |
ALL
|
Dirt |
FO-524PL05 |
Paper Filter |
5 |
2-100 USGPM |
FO-524PL1/2 |
0.5 |
FO-524PL25
|
25 |
(1) For aviation and diesel fuel applications, always install a differential pressure gauge or other means of determing differential pressure.
(2) See Data Sheet #1709 for absorbent cartridge (AC, AD) flow rates.
(3) See Data Sheet # 1532 for paper filter (FO) flow rates, see Data Sheet # 1747 for synthetic filter (FOS) flow rates.
(4) For Aviation Fuels, if system pressure can exceed 25 psi, and for Diesel Fuel Systems, always install pressure gauge or other means of determining differential pressure.
(5) For Full Flow Fuel Monitor applications, the flow rate can be increased to 100 USGPM. This will result in a somewhat reduced cartridge life and higher initial pressure drop. In jet fuel with an ACO-52401L installed, the initial pressure drop is 6 psi at 50 USGPM, 10 psi at 75 USGPM.
For Spin-on Filters, please see:
Datasheet 1769 -Aquacon® Spin-On
Filters for Jet fuel and Avgas -PDF (146 KB)
Datasheet 1717 -Aquacon® Spin-on Filters for fuels and oils - PDF (103 KB)
Datasheet 1720 -Aquacon® Hydraulic oil filters - PDF (361 KB)
OPTIONAL ACCESSORIES -
DIFFERENTIAL PRESSURE GAUGES
|
|
|
|
|
P/N 07-224
for VF-609
Optional Mounting block for gauge,
P/N 07-224AMB,
Not shown
|
|
|
